-
CDL PRE-TRIP VEHICLE INSPECTION
MEMORY AID
You may use this list of vehicle components during the test to help remember components you must inspect as
described in the Oregon Commercial Driver Manual. You need only inspect those components with which your vehicle
is equipped.
As much as possible, you should inspect the components on your vehicle in the order they are listed below. This will help
you conduct a methodical inspection without missing required components.
When visible or accessible, you must point at or touch the component you are inspecting. If your vehicle has the
component but it is not visible or accessible, describe its location. Explain to the examiner how you are or would inspect
the component. Specifically describe conditions that would lead you to believe an item or component is illegal or unsafe. If
your vehicle does not have listed components, skip them and go to the next component/area.
The pre-trip inspection tests
your familiarity with your ve
hicle and your abi
lity to identify unsafe or illegal vehicl
e
components. It is not representative of the complete inspection that you would perform daily.
● CLASS A VEHICLES ●
Engine Compartment Coupling Systems (Cont) Trailer Suspension
Fluid Levels
Pintle Hook/Ball Hitch Types
Air Compressor Pintle Hook/Ball Torque Arm/Radius Rod
Alternator Safety Latch/Locking Device
Rear of Trailer
Fluid Leaks and Hoses Safety Chains/Cables Doors or Ties
Front of Tractor/Truck
Eye/Coupler Mud Flaps
Lights and Reflectors
Steering Linkage
Tow Truck – Underlift Type
Front Lights
Front Suspension
Underlift Reach Rear Lights
Springs &/
or Air Bags Pivot Pin
Clearance and Reflectors
Engine Start – In Cab
Shock Absorber Receiver Retaining & Safety Pins Safety Belt
Driver/Fuel Area
Tie-Down Chains or Straps Lighting Indicators
Side of Trailer
Rear of Tractor/Truck
Landing Gear Ammeter/Voltmeter
Drive Shaft Doors or Ties Mirrors
Exhaust System Frame & Crossmembers Windshield
Frame Tandem Release Wipers and Washers
Trailer Wheels
Horn(s)
Electric Connectors and Lines Rims Heater/Defroster
Catwalk Tires Safety/Emergency Equipment
Headerboard Lug Nuts Hydraulic Brake Check
Coupling Systems
Hub/Axle Seal Breakaway Module
Fifth Wheel Type
Spacer or Bud Spacing Air Brake Checks
Mounting Bolts
Brakes
Parking Brake
Platform Slack Adjusters and Pushrods Service Brakes
5
th
Wheel Skid Plate Chambers
Release Arm Hoses/Lines
Kingpin Drums and Linings or Rotors and Pads
Apron
Sliding 5
th
Wheel Locking Pins
735-6892 (7 13)